AX-2025-021066 · Tirzepatide · BCH lot BCH-2501-D4197

Section 1

Results

Measured against the index acceptance specification for the incretin analogues and co-agonists class. A specification is a decision the index made; a result is a measurement. See where each threshold came from.

Parameter	Method	Result	Unit	Index spec
Purity	RP-HPLC, 30 min gradient, 214 nm	97.97	% area	≥ 97.0	PASS
Total impurities	RP-HPLC, sum of reported peaks	2.03	% area	≤ 3.0	PASS
Largest single impurity	RP-HPLC — trifluoroacetyl adduct (+96 Da)	1.40	% area	≤ 1.00	FAIL
Identity	not ordered on this submission	not determined	—	required for VERIFIED status	NOT TESTED
Total peptide content	by difference from the gravimetric mass balance	85.86	%w/w	—	NOT TESTED
Target-compound content	total peptide content × purity	84.12	%w/w	—	NOT TESTED
Gross fill (as weighed)	five-place balance, under nitrogen	65.94	mg	60 mg declared	NOT TESTED
Recovered target peptide	gross fill × target content	55.469	mg	60 mg claim	NOT TESTED
Recovery against label claim	recovered ÷ claim	92.4	%	90.0 – 110.0	PASS
Water content	Karl Fischer, coulometric, duplicate	4.12	%	≤ 8.0	PASS
Counter-ion (TFA)	anion-exchange ion chromatography	9.51	%	≤ 12.0	PASS
Residual solvent + inorganic residue	estimated — see /methods/residual-solvents-q3c/	0.51	%	—	NOT TESTED
Endotoxin	not ordered on this submission	not determined	—	≤ 5.0	NOT TESTED
Sterility	not ordered on this submission	not determined	—	no growth	NOT TESTED
Appearance	visual, diffuse light, black and white background	White to pale-yellow cake, intact	—	white to off-white intact cake	PASS
Reconstitution clarity	reconstituted per submitter procedure	Clear, colourless, no visible particulates	—	clear, no visible particulates	PASS
pH (reconstituted, 1 mg/mL)	potentiometric, two-point calibration	3.08	—	2.5 – 8.0	PASS
Retention time (observed)	RP-HPLC, 30 min gradient	19.84	min	19.86 ± 0.45 (normalised)	PASS
Peak asymmetry (10 % height)	Ph. Eur. 2.2.46	0.99	—	0.80 – 1.50	PASS
Plate count, main peak	N = 5.54 (t/w½)²	64,499	—	≥ 20,000	PASS
Resolution to nearest impurity	vs [D-Aib13]-diastereomer	0.59	—	no index criterion	REPORTED

Section 2

Chromatogram and peak integration

The figure is drawn from the table. It is not an independent illustration — if a number in the table changed, the trace would change with it.

Figure 1. RP-HPLC trace, 30 min gradient, 214 nm. Drawn from the peak-integration table below: peak positions are the reported retention times, peak areas are the reported area percentages, peak widths follow the reported plate count of 64,499, and skew follows the reported asymmetry factor of 0.99. Baseline noise is seeded from the report ID and is illustrative. The lower panel is the same trace at a stated vertical expansion with the slow gradient drift subtracted, because at full scale a 1.40 % impurity against a 97.97 % main peak is a line two pixels tall; the main peak runs off-scale there by design.

#	Peak	RT	Area (µV·s)	% area	Δ mass (Da)
1	Tirzepatide — main peak	19.84	4,761,646	97.97	—
2	trifluoroacetyl adduct (+96 Da)	20.77	68,044	1.40	+95.982
3	[D-Aib13]-diastereomer	19.65	19,927	0.41	0.000
4	C20 diacid mono-amide	21.46	6,804	0.14	+0.984
5	Met(O) sulfoxide (+16 Da)	19.10	2,430	0.05	+15.995
6	des-Gly deletion (−57 Da)	19.23	972	0.02	-57.021
7	tirzepatide dimer	23.82	486	0.01	+4810.410
Closure check — purity + Σ impurities				100.00	CLOSES

Reporting threshold 0.05 % area. Peaks below it are not reported and are therefore excluded from the total, which overstates purity by their sum — see peak integration.

Section 4

Gravimetric mass balance

Water, counter-ion, residual and total peptide content are exhaustive and mutually exclusive categories. They must account for 100 % of the cake mass. The index closes this to within 0.02 pp and the build asserts it.

Component	Determination	%w/w of cake
Water	Karl Fischer	4.12
Counter-ion (TFA)	ion chromatography	9.51
Residual solvent + inorganic residue	estimated	0.51
Total peptide content	by difference	85.86
Total		100.00 CLOSES

Supplier certificate, as declared

The supplier's own figures for this lot, beside the independent measurement. Divergence is assessed against the batch median, not against this single report — see rule AX-R05.

Figure	Supplier COA	This report	Index note
Purity (% area)	97.32	97.97	divergence +0.07 pp vs batch median
Total impurities (% area)	2.68	2.03
Largest single impurity (% area)	not stated	1.40
Water (%)	2.8	4.12
Counter-ion (%)	not stated	9.51
Peptide content (%w/w)	not stated	85.86
Endotoxin (EU/mg)	not stated	not determined
Method stated on certificate	YES	—	column, gradient and wavelength given

Section 5

Provenance and caveats

Where a sample came from changes the weight of the evidence. The index treats it as a first-class field.

Sample provenance: Supplier-supplied
Evidentiary weight: Weaker evidence. Read with the caveat below.
Chain of custody: Supplier despatch → laboratory direct (courier, cold pack, 2 d) → assay. Submitter did not handle the vial.
Assay date: 23 Apr 2025
Submitted to the index: 29 Apr 2025
Laboratory: Janoshik Analytical, Ostrava, Czechia
Method basis: 30 min gradient · high-resolution MS
Verification status: PURITY ONLY

What this report does not establish

That the compound is the compound named. No identity confirmation was ordered on this submission. A purity figure describes chromatographic homogeneity of whatever eluted; it does not name it.
That the material is free of bacterial endotoxin. Endotoxin was not measured. No chromatographic result bears on it.
That the material is sterile. Sterility was not tested.
That any other vial in the same lot has the same composition. One vial was tested. Within-lot vial-to-vial variation in this index has a median of 0.28 pp and a 90th percentile of 0.74 pp.
That any other lot from the same supplier has the same composition. Batch-to-batch variation is larger than within-batch variation for every supplier here.
That the material is suitable for administration to a human or an animal. These are research compounds. No result on this site is a safety assessment and the index takes no position on use.
That the material was manufactured by the supplier that sold it. Contract synthesis is normal in this market and twenty-nine batches in the index fingerprint to a bulk from a different company than the one named on the label.

Section 6

Annotations 3

Signed technical comments from index contributors. Not a discussion forum — annotations question or contextualise the result, and the data team replies where a reply is warranted.

sample_vs_retail29 Apr 2025

The result is published in full and weighted the same as any other in the raw dataset. Down-weighting happens in the sensitivity analyses, transparently, rather than silently at intake.

valley_drop29 Apr 2025

The index's position is that the integration convention must be stated, not that any particular convention must be used. Both are defensible; only one can be reported and it should be named.

units_pedant29 Apr 2025

Percent by weight of the cake throughout, stated once and applied consistently. Mixing bases across the four slots is the commonest way a balance fails to close.

Section 7

Related records

Same batch — lot BCH-2501-D4197 n=11

Report	Lot	Lab	Quarter	Purity %	Water %	Recovery %	Provenance	Flags	Result
AX-2025-021056	BCH-2501-D4197	VendorInvestigate	2025-Q2	96.88	4.95	—	Buyer-sourced	0	FAIL
AX-2025-021057	BCH-2501-D4197	PeptideMeter	2025-Q2	97.35	4.72	—	Buyer-sourced	1	FAIL
AX-2025-021058	BCH-2501-D4197	Nordanalyt	2025-Q2	97.25	4.12	—	Buyer-sourced	0	PASS
AX-2025-021059	BCH-2501-D4197	Janoshik	2025-Q2	98.17	4.88	—	Supplier-supplied	1	MARGINAL
AX-2025-021060	BCH-2501-D4197	Janoshik	2025-Q2	96.85	4.37	95.3	Buyer-sourced	0	FAIL
AX-2025-021061	BCH-2501-D4197	Janoshik	2025-Q2	97.00	4.10	101.2	Buyer-sourced	0	PASS
AX-2025-021062	BCH-2501-D4197	Medutest	2025-Q2	97.49	4.70	—	Supplier-supplied	2	FAIL
AX-2025-021063	BCH-2501-D4197	Medutest	2025-Q2	96.84	4.83	—	Buyer-sourced	0	FAIL
AX-2025-021064	BCH-2501-D4197	PeptideMeter	2025-Q2	97.50	4.57	—	Buyer-sourced	0	PASS
AX-2025-021065	BCH-2501-D4197	PeptideMeter	2025-Q2	97.11	4.05	101.4	Buyer-sourced	0	PASS

Batch rollup and reproducibility assessment →

Cross-sections

Other recent Tirzepatide records in the index.
Report	Supplier	Lot	Lab	Quarter	Purity %	Water %	Recovery %	Provenance	Result
AX-2026-043288	CPC	CPC-2607-L1516	Janoshik	2026-Q3	96.89	5.11	101.1	Laboratory-retained	FAIL
AX-2026-041610	FGP	FGP-2603-L7753	Janoshik	2026-Q3	98.81	2.45	101.0	Buyer-sourced	PASS
AX-2026-041974	AMB	AMB-2603-C5112	Nordanalyt	2026-Q3	98.20	3.41	—	Buyer-sourced	PASS
AX-2026-041975	AMB	AMB-2603-C5112	Medutest	2026-Q3	97.88	3.45	106.9	Laboratory-retained	PASS
AX-2026-041609	FGP	FGP-2603-L7753	Janoshik	2026-Q3	98.52	2.00	98.0	Buyer-sourced	PASS
AX-2026-041978	AMB	AMB-2603-C5112	Janoshik	2026-Q3	97.94	3.57	103.0	Buyer-sourced	PASS
AX-2026-041982	AMB	AMB-2603-C5112	Janoshik	2026-Q3	97.60	4.46	—	Buyer-sourced	PASS
AX-2026-043286	CPC	CPC-2607-L1516	Kestrel	2026-Q3	98.20	4.56	—	Buyer-sourced	PASS

Other recent BCH records in the index.
Report	Compound	Lot	Lab	Quarter	Purity %	Water %	Recovery %	Provenance	Flags	Result
AX-2026-043445	BPC-157	BCH-2603-G4350	Nordanalyt	2026-Q3	98.42	4.87	93.6	Buyer-sourced	1	MARGINAL
AX-2026-043440	BPC-157	BCH-2603-G4350	VendorInvestigate	2026-Q3	98.61	4.11	—	Buyer-sourced	1	MARGINAL
AX-2026-043442	BPC-157	BCH-2603-G4350	Janoshik	2026-Q3	98.65	4.78	—	Buyer-sourced	1	MARGINAL
AX-2026-043471	CJC-1295 with DAC	BCH-2607-H5235	Janoshik	2026-Q3	97.46	5.48	—	Buyer-sourced	1	FAIL
AX-2026-043477	CJC-1295 with DAC	BCH-2607-H5235	VendorInvestigate	2026-Q3	97.62	5.32	99.6	Buyer-sourced	1	MARGINAL
AX-2026-043449	BPC-157	BCH-2603-G4350	Kestrel	2026-Q3	99.74	4.92	91.3	Supplier-supplied	2	MARGINAL
AX-2026-043448	BPC-157	BCH-2603-G4350	Janoshik	2026-Q3	98.55	4.69	106.9	Buyer-sourced	1	MARGINAL
AX-2026-043470	CJC-1295 with DAC	BCH-2607-H5235	Janoshik	2026-Q3	97.76	6.11	99.3	Supplier-supplied	1	MARGINAL